Citation: Xishou Guo, Haochun Wang, Zixin Ma, Jinlong Wang, Yuchao Tang, Guibai Li, Heng Liang, Xiaobin Tang. Insight into the role and mechanism of combined GAC and magnetic particles in achieving gravity-driven membrane performance enhancement[J]. Chinese Chemical Letters, ;2025, 36(10): 110781. doi: 10.1016/j.cclet.2024.110781 shu

Insight into the role and mechanism of combined GAC and magnetic particles in achieving gravity-driven membrane performance enhancement

Xishou Guo ^{a, 1} ,
Haochun Wang ^{a, 1} ,
Zixin Ma ^a ,
Jinlong Wang ^a ,
Yuchao Tang ^b ,
Guibai Li ^a ,
Heng Liang ^a ,
Xiaobin Tang ^{a, *,}

a.
State Key Laboratory of Urban Water Resource and Environment (SKLUWRE), Harbin Institute of Technology, Harbin 150090, China
b.
Provincial Key Laboratory of Environmental Pollution Control and Resource Reuse), Anhui Jianzhu University, Hefei 230601, China

tang5462@163.com

Received Date: 20 July 2024
Revised Date: 27 November 2024
Accepted Date: 18 December 2024
Available Online: 20 December 2024

Figures(5)

Gravity-driven membrane filtration (GDM) has increasingly captured researchers' attention due to its low energy consumption and operation & maintenance. However, severe membrane fouling and permeate DOC increase restricted GDM's widespread application. This study combined granular active carbon (GAC) and magnetic particles to address this issue and results suggested that GDM3 achieved highly effective pollutant removals (85% COD_Mn, 95% UV₂₅₄, and 65% DOC) and significant flux improvement (96%) than GDM itself. GAC pretreatment before the membrane mainly helped to reduce pollutant load and improve permeated quality while magnetic particles in situ on the membrane surface contributed to engineering more open and connected structures with less extracellular polymeric substance (EPS) and soluble microbial products (SMP) than other GDM groups due to their bioeffect. GDM3 was cost-effective and had the lowest total cost with a decrease of 7.5% and 5.7% to GDM1 and GDM2. The findings provided a deep insight into the combined GAC and magnetic particles in GDM performance improvement and played a fundamental role in developing sustainable and environmentally friendly GDM processes.
- Gravity-driven membrane (GDM),
- Magnetic particles,
- Bioeffect,
- Biocake layer
1. [1]
  M. Peter-Varbanets, F. Hammes, M. Vital, et al., Water Res. 44 (2010) 3607–3616. doi: 10.1016/j.watres.2010.04.020
2. [2]
  Y.T. Tsai, I.V. Maggay, A. Venault, et al., Sep. Purif. Technol. 279 (2021) 119720. doi: 10.1016/j.seppur.2021.119720
3. [3]
  W. Pronk, A. Ding, E. Morgenroth, et al., Water Res. 149 (2019) 553–565. doi: 10.1016/j.watres.2018.11.062
4. [4]
  X. Guo, S. Jiang, Y. Wang, et al., Sep. Purif. Technol. 303 (2022) 122122. doi: 10.1016/j.seppur.2022.122122
5. [5]
  B. Wu, F. Hochstrasser, E. Akhondi, et al., Water Res. 93 (2016) 133–140. doi: 10.1016/j.watres.2016.02.021
6. [6]
  A. Ding, J.L. Wang, D.C. Lin, et al., Chemosphere 191 (2018) 253–261. doi: 10.1016/j.chemosphere.2017.10.034
7. [7]
  J.L. Wang, X.B. Tang, Y.Y. Liu, et al., Resour. Conserv. Recycl. 177 (2022) 106008. doi: 10.1016/j.resconrec.2021.106008
8. [8]
  J. Zhang, S. Yu, J. Wang, et al., Water Res. 231 (2023) 119606. doi: 10.1016/j.watres.2023.119606
9. [9]
  X. Tang, W. Pronk, A. Ding, et al., Chem. Eng. J. 333 (2018) 289–299. doi: 10.1016/j.cej.2017.09.111
10. [10]
  S. Shao, Y. Feng, H. Yu, et al., Water Res. 108 (2017) 240–249. doi: 10.1016/j.watres.2016.10.081
11. [11]
  J. Ding, H. Xiao, X. Huang, et al., Chin. Chem. Lett. 34 (2023) 108316. doi: 10.1016/j.cclet.2023.108316
12. [12]
  X.B. Tang, B.H. Xie, R. Chen, et al., Chem. Eng. J. 397 (2020) 125248. doi: 10.1016/j.cej.2020.125248
13. [13]
  A. Chomiak, B. Sinnet, N. Derlon, et al., Water Res. 64 (2014) 177–186. doi: 10.1016/j.watres.2014.06.045
14. [14]
  Y. Liu, Q. Liu, J. Li, et al., Bioresour. Technol. 249 (2018) 377–385. doi: 10.1016/j.biortech.2017.10.027
15. [15]
  H. He, X. Xin, W. Qiu, et al., Water Res. 209 (2022) 117897. doi: 10.1016/j.watres.2021.117897
16. [16]
  X. Guo, Y. Wang, S. Jiang, et al., Chemosphere 310 (2023) 136692. doi: 10.1016/j.chemosphere.2022.136692
17. [17]
  J. Wang, X. Tang, X. Cheng, et al., Desalination 516 (2021) 115243. doi: 10.1016/j.desal.2021.115243
18. [18]
  Q.K. Hong, K.M. Wang, C.H. Wu, et al., J. Environ. Chem. Eng. 11 (2023) 109436. doi: 10.1016/j.jece.2023.109436
19. [19]
  G.U. Semblante, S.D.R. Tampubolon, S.J. You, et al., J. Membr. Sci. 435 (2013) 62–70. doi: 10.1016/j.memsci.2013.02.003
20. [20]
  W.X. Zhang, F. Jiang, Water Res. 157 (2019) 445–453. doi: 10.1016/j.watres.2018.07.069
21. [21]
  X. Tang, A. Ding, W. Pronk, et al., J. Cleaner Prod. 197 (2018) 721–731. doi: 10.1016/j.jclepro.2018.06.155
22. [22]
  H. Wang, Z. Chen, J. Miao, et al., Bioresour. Technol. 209 (2016) 318–325. doi: 10.1016/j.biortech.2016.03.010
23. [23]
  R. Chen, H. Zhang, J. Wang, et al., Water Res. 224 (2022) 119111. doi: 10.1016/j.watres.2022.119111
24. [24]
  R. Chen, H. Zhang, D. Lin, et al., Resour., Conserv. Recycl. 190 (2023) 106839. doi: 10.1016/j.resconrec.2022.106839
25. [25]
  S.J. Ballinger, I.M. Head, T.P. Curtis, et al., Water Sci. Technol. 46 (2002) 543–550. doi: 10.2166/wst.2002.0532
26. [26]
  R. Chen, H. Liang, J.L. Wang, et al., Sci. Total Environ. 771 (2021) 145372. doi: 10.1016/j.scitotenv.2021.145372
27. [27]
  T. Cavalier-Smith, Int. J. Syst. Evol. Microbiol. 52 (2002) 297–354. doi: 10.1099/00207713-52-2-297
28. [28]
  N. Derlon, N. Koch, B. Eugster, et al., Water Res. 47 (2013) 2085–2095. doi: 10.1016/j.watres.2013.01.033
29. [29]
  B. Ma, S. Wang, Z. Li, et al., Bioresour. Technol. 225 (2017) 377–385. doi: 10.1016/j.biortech.2016.11.130
1. [1]
  Bing Niu , Honggao Huang , Liwei Luo , Li Zhang , Jianbo Tan . Coating colloidal particles with a well-defined polymer layer by surface-initiated photoinduced polymerization-induced self-assembly and the subsequent seeded polymerization. Chinese Chemical Letters, 2025, 36(2): 110431-. doi: 10.1016/j.cclet.2024.110431
2. [2]
  Dan Shao , Yujing Lyu , Chengyuan Liu , Hao Wang , Ning Ma , Hao Xu , Wei Yan , Xiaohua Jia , Haojie Song . Attracting magnetic BDD particles onto Ti/RuO₂-IrO₂ by using a magnet: A novel 2.5-dimensional electrode for electrochemical oxidation wastewater treatment. Chinese Chemical Letters, 2025, 36(6): 110641-. doi: 10.1016/j.cclet.2024.110641
3. [3]
  Hao Zhang , Haonan Qu , Ehsan Bahojb Noruzi , Haibing Li , Feng Liang . A nanocomposite film with layer-by-layer self-assembled gold nanospheres driven by cucurbit[7]uril for the selective transport of L-tryptophan and lysozyme. Chinese Chemical Letters, 2025, 36(1): 109731-. doi: 10.1016/j.cclet.2024.109731
4. [4]
  Guang-Xu Duan , Queting Chen , Rui-Rui Shao , Hui-Huang Sun , Tong Yuan , Dong-Hao Zhang . Encapsulating lipase on the surface of magnetic ZIF-8 nanosphers with mesoporous SiO₂ nano-membrane for enhancing catalytic performance. Chinese Chemical Letters, 2025, 36(2): 109751-. doi: 10.1016/j.cclet.2024.109751
5. [5]
  Tiankai Sun , Hui Min , Zongsu Han , Liang Wang , Peng Cheng , Wei Shi . Rapid detection of nanoplastic particles by a luminescent Tb-based coordination polymer. Chinese Chemical Letters, 2024, 35(5): 108718-. doi: 10.1016/j.cclet.2023.108718
6. [6]
  Yimin Guo , Yiting Luo , Shuwen Hua , Chuan-Fan Ding , Yinghua Yan . Application of magnetic nanomaterials in peptidomics: A review in the past decade. Chinese Chemical Letters, 2025, 36(6): 110070-. doi: 10.1016/j.cclet.2024.110070
7. [7]
  Jiajia Zhuang , Chunyu Cui , Changjiang Li , Gang Luo , Jiaping Tong , Di Sun . Counter-ion effect to the Ising-type magnetic anisotropy and magnetic relaxation in trigonal bipyramidal Co(Ⅱ) complexes. Chinese Chemical Letters, 2025, 36(7): 110091-. doi: 10.1016/j.cclet.2024.110091
8. [8]
  Huihui LIU , Baichuan ZHAO , Chuanhui WANG , Zhi WANG , Congyun ZHANG . Green synthesis of MIL-101/Au composite particles and their sensitivity to Raman detection of thiram. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 2021-2030. doi: 10.11862/CJIC.20240059
9. [9]
  Xianping Du , Ying Huang , Chen Chen , Zhenhe Feng , Meng Zong . Encapsulating Si particles in multiple carbon shells with pore-rich for constructing free-standing anodes of lithium storage. Chinese Chemical Letters, 2024, 35(12): 109990-. doi: 10.1016/j.cclet.2024.109990
10. [10]
  Di ZHANG , Tianxiang XIE , Xu HE , Wanyu WEI , Qi FAN , Jie QIAO , Gang JIN , Ningbo LI . Construction and antitumor activity of pH/GSH dual-responsive magnetic nanodrug. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 786-796. doi: 10.11862/CJIC.20240329
11. [11]
  Ke Xu , Shulai Lei , Panshuo Wang , Weiyi Wang , Yuan Feng , Junsheng Feng . Unraveling the microscopic origin of out of plane magnetic anisotropy in Ⅵ₃. Chinese Chemical Letters, 2025, 36(8): 110257-. doi: 10.1016/j.cclet.2024.110257
12. [12]
  Jie Wu , Xiaoqing Yu , Guoxing Li , Su Chen . Engineering particles towards 3D supraballs-based passive cooling via grafting CDs onto colloidal photonic crystals. Chinese Chemical Letters, 2024, 35(4): 109234-. doi: 10.1016/j.cclet.2023.109234
13. [13]
  Peng Zhang , Yitao Yang , Tian Qin , Xueqiu Wu , Yuechang Wei , Jing Xiong , Xi Liu , Yu Wang , Zhen Zhao , Jinqing Jiao , Liwei Chen . Interface engineering of Pt/CeO₂-{100} catalysts for enhancing catalytic activity in auto-exhaust carbon particles oxidation. Chinese Chemical Letters, 2025, 36(2): 110396-. doi: 10.1016/j.cclet.2024.110396
14. [14]
  Yue Li , Minghao Fan , Conghui Wang , Yanxun Li , Xiang Yu , Jun Ding , Lei Yan , Lele Qiu , Yongcai Zhang , Longlu Wang . 3D layer-by-layer amorphous MoS_x assembled from [Mo₃S₁₃]^2- clusters for efficient removal of tetracycline: Synergy of adsorption and photo-assisted PMS activation. Chinese Chemical Letters, 2024, 35(9): 109764-. doi: 10.1016/j.cclet.2024.109764
15. [15]
  Min Chen , Boyu Peng , Xuyun Guo , Ye Zhu , Hanying Li . Polyethylene interfacial dielectric layer for organic semiconductor single crystal based field-effect transistors. Chinese Chemical Letters, 2024, 35(4): 109051-. doi: 10.1016/j.cclet.2023.109051
16. [16]
  Xinxiu Yan , Xizhe Huang , Yangyang Liu , Weishang Jia , Hualin Chen , Qi Yao , Tao Chen . Hyperbranched polyamidoamine protective layer with phosphate and carboxyl groups for dendrite-free Zn metal anodes. Chinese Chemical Letters, 2024, 35(10): 109426-. doi: 10.1016/j.cclet.2023.109426
17. [17]
  Yanrui Liu , Paramaguru Ganesan , Peng Gao . Harnessing d-f transition rare earth complexes for single layer white organic light emitting diodes. Chinese Journal of Structural Chemistry, 2024, 43(9): 100369-100369. doi: 10.1016/j.cjsc.2024.100369
18. [18]
  Run Chai , Qiujie Wu , Yongchao Liu , Xiaohui Song , Xuyong Feng , Yi Sun , Hongfa Xiang . A 3D dual layer host with enhanced sodiophilicity as stable anode for high-energy sodium metal batteries. Chinese Chemical Letters, 2025, 36(6): 110007-. doi: 10.1016/j.cclet.2024.110007
19. [19]
  Bao Li , Pengyao Yan , Mengmin Jia , Liang Wang , Yaru Qiao , Haowen Li , Canhui Wu , Zhuangzhuang Zhang , Dongmei Dai , Dai-Huo Liu . Engineering lithiophilic LiC_x layer to robust interfacial chemistry between LAGP and Li anode for Li-metal batteries. Chinese Chemical Letters, 2025, 36(7): 110145-. doi: 10.1016/j.cclet.2024.110145
20. [20]
  Long Huang , Jian Pu , Yunyu Zhao , Xiangxiang Fang , Yingjian Yu , Yuan Li , Jinyan Ma , Yuejin Zhu , Fang Hu , Chuang Yue . Phosphorus-doped carbon as an effective protective layer for advanced aqueous zinc-ion batteries. Chinese Chemical Letters, 2025, 36(8): 110989-. doi: 10.1016/j.cclet.2025.110989

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(83)
HTML views(0)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142