Citation: Fan Siqi, Wang Yue, Li Zhuoshi, Zeng Zhuang, Guo Shaoxia, Huang Shouying, Ma Xinbin. Carbon layer-coated ordered mesoporous silica supported Co-based catalysts for higher alcohol synthesis: The role of carbon source[J]. Chinese Chemical Letters, ;2020, 31(2): 525-529. doi: 10.1016/j.cclet.2019.04.070 shu

Carbon layer-coated ordered mesoporous silica supported Co-based catalysts for higher alcohol synthesis: The role of carbon source

Key Laboratory for Green Chemical Technology of Ministry of Education, Collaborative Innovation Centre of Chemical Science and Engineering, School of Chemical Engineering and Technology, Tianjin University, Tianjin 300350, China

yuewang@tju.edu.cn

Received Date: 2 April 2019
Revised Date: 27 April 2019
Accepted Date: 29 April 2019
Available Online: 29 April 2019

Figures(3)

Surface chemical properties of supports have an important influence on active sites and their catalytic behavior. Here, we fabricated a series of cobalt-based catalysts supported by carbon layer-coated ordered mesoporous silica (OMS) composites for higher alcohol synthesis (HAS). The carbon layers were derived from different sources and uniformly coated on the porous surface of OMS. Combined with the characterization results of carbonized catalysts, it is demonstrated that the carbon layer-coated supports significantly enhanced the metal dispersion and increased the ratio of Co²⁺ to Co⁰ sites, which further increased the CO conversion and alcohols selectivity. Moreover, it is found that the catalytic activity changed in line with the amount of defects and surface oxygenic groups of carbon layers, which resulted from the different carbon sources. The highest space time yield of C₂₊OH was 27.5 mmol g_cat^-1 h^-1) obtained by the catalyst coated with glucose-derived carbon layer. But the carbon source is not the key factor influencing the distribution of Co-Co²⁺ dual sites and shows little effect on selectivity in HAS. These results may guide for further design of carbon supported catalysts.
- Syngas,
- Higher alcohols,
- Cobalt-based catalysts,
- Carbon layer-coated support,
- Carbon source
1. [1]
  L. Siwale, L. Kristóf, A. Bereczky, M. Mbarawa, A. Kolesnikov, Fuel Process. Technol. 118(2014) 318-326. doi: 10.1016/j.fuproc.2013.10.007
2. [2]
  Q. Mei, X. Shen, H. Liu, B. Han, Chin. Chem. Lett. 30(2019) 15-24. doi: 10.1016/j.cclet.2018.04.032
3. [3]
  G.A. Mills, Fuel 73(1994) 1243-1279. doi: 10.1016/0016-2361(94)90301-8
4. [4]
  L. Zhong, F. Yu, Y. An, et al., Nature 538(2016) 84. doi: 10.1038/nature19786
5. [5]
  N.D. Subramanian, G. Balaji, C. Kumar, J.J. Spivey, Catal. Today 147(2009) 100-106. doi: 10.1016/j.cattod.2009.02.027
6. [6]
  R.G. Herman, Catal. Today 55(2000) 233-245. doi: 10.1016/S0920-5861(99)00246-1
7. [7]
  J. Su, Z. Zhang, D. Fu, et al., J. Catal. 336(2016) 94-106. doi: 10.1016/j.jcat.2016.01.015
8. [8]
  S. Carenco, A. Tuxen, M. Chintapalli, et al., J. Phys. Chem. C 117(2013) 6259-6266. doi: 10.1021/jp4000297
9. [9]
  Y. Yang, X. Qi, X. Wang, et al., Catal. Today 270(2016) 101-107. doi: 10.1016/j.cattod.2015.06.014
10. [10]
  W. Zi, G. Laddha, S. Kanitkar, J.J. Spivey, Catal. Today 298(2017) 209-215. doi: 10.1016/j.cattod.2017.04.035
11. [11]
  X. Song, Y. Ding, W. Chen, et al., Energ. Fuel 26(2012) 6559-6566. doi: 10.1021/ef301391f
12. [12]
  T. Chen, J. Su, Z. Zhang, et al., ACS Catal. 8(2018) 8606-8617. doi: 10.1021/acscatal.8b00453
13. [13]
  H.N. Pham, A.E. Anderson, R.L. Johnson, et al., ACS Catal. 5(2015) 4546-4555. doi: 10.1021/acscatal.5b00329
14. [14]
  H. Xiong, Y. Zhang, K. Liew, J. Li, J. Mol. Catal. A 295(2008) 68-76. doi: 10.1016/j.molcata.2008.08.017
15. [15]
  V.N. Mochalin, O. Shenderova, D. Ho, Y. Gogotsi, Nat. Nanotechnol. 7(2012) 11-23. doi: 10.1038/nnano.2011.209
16. [16]
  Y. Chen, G. Zhao, L. Lin, Chin. Chem. Lett. 29(2018) 1633-1636. doi: 10.1016/j.cclet.2018.01.055
17. [17]
  X. Dong, X.L. Liang, H.Y. Li, et al., Catal. Today 147(2009) 158-165. doi: 10.1016/j.cattod.2008.11.025
18. [18]
  Y.P. Pei, J.X. Liu, Y.H. Zhao, et al., ACS Catal. 5(2015) 3620-3624. doi: 10.1021/acscatal.5b00791
19. [19]
  D. Zhao, J. Feng, Q. Huo, et al., Science 279(1998) 548-552. doi: 10.1126/science.279.5350.548
20. [20]
  L. Dai, W. Bo, F. Tan, et al., Bioresource Technol. 161(2014) 327-332. doi: 10.1016/j.biortech.2014.03.086
21. [21]
  R. Schmidt, E.W. Hansen, M. Stoecker, D. Akporiaye, O.H. Ellestad, J. Am. Chem. Soc. 117(1995) 4049-4056. doi: 10.1021/ja00119a021
22. [22]
  D.S.T.Martinez, J.P.V. Damasceno, L.S. Franqui, et al., Mater.Sci. Eng.C78(2017) 141-150. doi: 10.1016/j.msec.2017.03.298
23. [23]
  H. Nishihara, Y. Fukura, K. Inde, et al., Carbon 46(2008) 48-53. doi: 10.1016/j.carbon.2007.10.024
24. [24]
  H. Nishihara, T. Kwon, Y. Fukura, et al., Chem. Mater. 23(2011) 3144-3151. doi: 10.1021/cm103388y
25. [25]
  X.Y. Liu, L.B. Sun, X.D. Liu, et al., ACS Appl. Mater. Inter. 5(2013) 9823-9829. doi: 10.1021/am403033z
26. [26]
  K. Krishnamoorthy, U. Navaneethaiyer, R. Mohan, J. Lee, S.J. Kim, Appl. Nanosci. 2(2012) 119-126. doi: 10.1007/s13204-011-0045-9
27. [27]
  K. Krishnamoorthy, M. Veerapandian, K. Yun, S.J. Kim, Carbon 53(2013) 38-49. doi: 10.1016/j.carbon.2012.10.013
28. [28]
  F. Coloma, A. Sepulvedaescribano, F. Rodriguezreinoso, J. Catal. 154(1995) 299-305. doi: 10.1006/jcat.1995.1171
29. [29]
  A.C. Ferrari, J. Robertson, Phys. Rev. B 61(2000) 14095-14107. doi: 10.1103/PhysRevB.61.14095
30. [30]
  T.Y. Kim, H.W. Lee, M. Stoller, et al., ACS Nano 5(2011) 436-442. doi: 10.1021/nn101968p
31. [31]
  I. Jung, D.A. Dikin, R.D. Piner, R.S. Ruoff, Nano Lett. 8(2008) 4283-4287. doi: 10.1021/nl8019938
32. [32]
  D.M. Hercules, J. Electron Spectrosc. 5(1974) 811-826. doi: 10.1016/0368-2048(74)85054-1
33. [33]
  A. Ambrosi, M. Pumera, Chem.-Eur. J. 19(2013) 4748-4753. doi: 10.1002/chem.201204226
34. [34]
  S. Reiche, R. Blume, X.C. Zhao, et al., Carbon 77(2014) 175-183. doi: 10.1016/j.carbon.2014.05.019
35. [35]
  P. Serp, B. Machado, Nanostructured Carbon Materials for Catalysis, (Catalysis Series), Royal Society of Chemistry, London, 2015.
36. [36]
  B.F. Machado, O. Mustapha, A.M. Rosa, et al., J. Catal. 309(2014) 185-198. doi: 10.1016/j.jcat.2013.09.016
37. [37]
  C. Liu, Y. He, L. Wei, et al., ACS Catal. 8(2018) 1591-1600. doi: 10.1021/acscatal.7b03887
38. [38]
  M. Franz, H.A. Arafat, N.G. Pinto, Carbon 38(2000) 1807-1819. doi: 10.1016/S0008-6223(00)00012-9
39. [39]
  J.C. Mohandas, M.K. Gnanamani, G. Jacobs, et al., ACS Catal. 1(2011) 1581-1588. doi: 10.1021/cs200236q
40. [40]
  X. Zhou, G.J.A. Mannie, J. Yin, et al., ACS Catal. 8(2018) 7326-7333. doi: 10.1021/acscatal.8b02076
1. [1]
  Peng Wang , Daijie Deng , Suqin Wu , Li Xu . Cobalt-based deep eutectic solvent modified nitrogen-doped carbon catalyst for boosting oxygen reduction reaction in zinc-air batteries. Chinese Journal of Structural Chemistry, 2024, 43(1): 100199-100199. doi: 10.1016/j.cjsc.2023.100199
2. [2]
  Daheng Wen , Weiwei Fang , Yongmei Liu , Tao Tu . Valorization of carbon dioxide with alcohols. Chinese Chemical Letters, 2024, 35(7): 109394-. doi: 10.1016/j.cclet.2023.109394
3. [3]
  Jin Long , Xingqun Zheng , Bin Wang , Chenzhong Wu , Qingmei Wang , Lishan Peng . Improving the electrocatalytic performances of Pt-based catalysts for oxygen reduction reaction via strong interactions with single-CoN₄-rich carbon support. Chinese Chemical Letters, 2024, 35(5): 109354-. doi: 10.1016/j.cclet.2023.109354
4. [4]
  Huiyuan Deng , Na Zhao , Junjie You , Zhicheng Pan , Bo Xing , Yuling Ye , Bo Lai , Yuxi Wang , Tongrui Lu , Xiaonan Liu . Removal of bisphenol a through peroxymonosulfate activation with N-doped graphite carbon spheres coated cobalt nanoparticles catalyst: Synergy of nonradicals. Chinese Chemical Letters, 2025, 36(8): 110650-. doi: 10.1016/j.cclet.2024.110650
5. [5]
  Cong Gao , Zijian Zhu , Siwei Li , Zheng Xi , Qingqing Sun , Jie Han , Rong Guo . Chiral supramolecular catalysts of helical nanoribbon: More twist, higher enantioselectivity. Chinese Chemical Letters, 2025, 36(3): 109968-. doi: 10.1016/j.cclet.2024.109968
6. [6]
  Zhikang Wu , Guoyong Dai , Qi Li , Zheyu Wei , Shi Ru , Jianda Li , Hongli Jia , Dejin Zang , Mirjana Čolović , Yongge Wei . POV-based molecular catalysts for highly efficient esterification of alcohols with aldehydes as acylating agents. Chinese Chemical Letters, 2024, 35(8): 109061-. doi: 10.1016/j.cclet.2023.109061
7. [7]
  Hongren RONG , Gexiang GAO , Zhiwei LIU , Ke ZHOU , Lixin SU , Hao HUANG , Wenlong LIU , Qi LIU . High-performance supercapacitor based on 1D cobalt-based coordination polymer. Chinese Journal of Inorganic Chemistry, 2025, 41(6): 1183-1195. doi: 10.11862/CJIC.20250034
8. [8]
  Shuangyu Wu , Jian Peng , Yue Jiang , Sijie Lin . The overlooked promotional effects of alcohols to BiOBr catalysts in photocatalytic degradation of organic pollutants. Chinese Chemical Letters, 2025, 36(11): 110819-. doi: 10.1016/j.cclet.2025.110819
9. [9]
  Peng Guo , Shicheng Dong , Xiang-Gui Zhang , Bing-Bin Yang , Jun Zhu , Ke-Yin Ye . Cobalt-catalyzed migratory carbon-carbon cross-coupling of borabicyclo[3.3.1]nonane (9-BBN) borates. Chinese Chemical Letters, 2025, 36(4): 110052-. doi: 10.1016/j.cclet.2024.110052
10. [10]
  Haiyang Peng , Zhipeng Xie , Shuiqing Lu , Da Zhang , Bin Yang , Feng Liang . Dual-functionality composites of polyaniline-coated oxidized carbon nanohorns: Efficient wave absorption and enhanced corrosion resistance. Chinese Chemical Letters, 2025, 36(6): 110818-. doi: 10.1016/j.cclet.2025.110818
11. [11]
  Maomao Liu , Guizeng Liang , Ningce Zhang , Tao Li , Lipeng Diao , Ping Lu , Xiaoliang Zhao , Daohao Li , Dongjiang Yang . Electron-rich Ni2+ in Ni3S2 boosting electrocatalytic CO2 reduction to formate and syngas. Chinese Journal of Structural Chemistry, 2024, 43(8): 100359-100359. doi: 10.1016/j.cjsc.2024.100359
12. [12]
  Xingxing Jiang , Yuxin Zhao , Yan Kong , Jianju Sun , Shangzhao Feng , Xin Lu , Qi Hu , Hengpan Yang , Chuanxin He . Support effect and confinement effect of porous carbon loaded tin dioxide nanoparticles in high-performance CO₂ electroreduction towards formate. Chinese Chemical Letters, 2025, 36(1): 109555-. doi: 10.1016/j.cclet.2024.109555
13. [13]
  Long Huang , Jian Pu , Yunyu Zhao , Xiangxiang Fang , Yingjian Yu , Yuan Li , Jinyan Ma , Yuejin Zhu , Fang Hu , Chuang Yue . Phosphorus-doped carbon as an effective protective layer for advanced aqueous zinc-ion batteries. Chinese Chemical Letters, 2025, 36(8): 110989-. doi: 10.1016/j.cclet.2025.110989
14. [14]
  Tianjun Ni , Hui Zhang , Liping Zhou , Roujie Ma , Yanyu Wang , Zhijun Yang , Dan Luo , Nithima Khaorapapong , Xingtao Xu , Yusuke Yamauchi , Dong Liu . Atomic cobalt catalysts on 3D interconnected g-C₃N₄ support for activation of peroxymonosulfate: The importance of Co-N coordination effect. Chinese Chemical Letters, 2025, 36(9): 110659-. doi: 10.1016/j.cclet.2024.110659
15. [15]
  Chenghao Liu , Xiaofeng Lin , Jing Liao , Min Yang , Min Jiang , Yue Huang , Zhizhi Du , Lina Chen , Sanjun Fan , Qitong Huang . Carbon dots-based dopamine sensors: Recent advances and challenges. Chinese Chemical Letters, 2024, 35(12): 109598-. doi: 10.1016/j.cclet.2024.109598
16. [16]
  Wei-Jia Wang , Kaihong Chen . Molecular-based porous polymers with precise sites for photoreduction of carbon dioxide. Chinese Chemical Letters, 2025, 36(1): 109998-. doi: 10.1016/j.cclet.2024.109998
17. [17]
  Quan Zhang , Shunjie Xing , Jingqian Han , Li Feng , Jianchun Li , Zhaosheng Qian , Jin Zhou . Organic pollutant sensing for human health based on carbon dots. Chinese Chemical Letters, 2025, 36(1): 110117-. doi: 10.1016/j.cclet.2024.110117
18. [18]
  Zhanheng Yan , Weiqing Su , Weiwei Xu , Qianhui Mao , Lisha Xue , Huanxin Li , Wuhua Liu , Xiu Li , Qiuhui Zhang . Carbon-based quantum dots/nanodots materials for potassium ion storage. Chinese Chemical Letters, 2025, 36(4): 110217-. doi: 10.1016/j.cclet.2024.110217
19. [19]
  Shimei Wu , Yining Li , Lantao Chen , Yufei Zhang , Lingxing Zeng , Haosen Fan . Hexapod cobalt phosphosulfide nanorods encapsulating into multiple hetero-atom doped carbon frameworks for advanced sodium/potassium ion battery anodes. Chinese Chemical Letters, 2025, 36(4): 109796-. doi: 10.1016/j.cclet.2024.109796
20. [20]
  Yining Li , Shimei Wu , Lantao Chen , Haosen Fan , Yufei Zhang , Lingxing Zeng . Multiple yolks-shell cobalt phosphosulfide nanocrystals encapsulating into rich heteroatoms co-doped carbon frameworks for advanced sodium/potassium ion batteries. Chinese Chemical Letters, 2025, 36(9): 110371-. doi: 10.1016/j.cclet.2024.110371

Get Citation

PDF

XML

Metrics

PDF Downloads(9)
Abstract views(1700)
HTML views(122)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142