Citation: Xiang-Li Meng, Gen-Hua Yu, Jian Ma. Preparation and Properties of Poly(aryl ether sulfone ketone) Ultrafiltration Membrane Containing Fluorene Group for High Temperature Condensed Water Treatment[J]. Chinese Journal of Polymer Science, ;2018, 36(8): 970-978. doi: 10.1007/s10118-018-2142-7 shu

Preparation and Properties of Poly(aryl ether sulfone ketone) Ultrafiltration Membrane Containing Fluorene Group for High Temperature Condensed Water Treatment

School of Chemistry and Chemical Engineering, Harbin Institute of Technology, Harbin 150001, China

Corresponding author: Xiang-Li Meng, mengxl2009@hit.edu.cn
Received Date: 13 March 2017
Revised Date: 5 April 2018
Accepted Date: 7 April 2018
Available Online: 11 May 2018

Novel poly(aryl ether sulfone ketone)s (PAESK) were synthesized from bisphenol A (BPA), 9,9′-bis(4-hydroxyphenyl) fluorene (BHPF), 4,4′-dichlorodiphenylsulfone (DCS) and 4,4′-difluorobenzophenone (DFB) via nucleophilic substitution polymerization, which were subsequently used to fabricate ultrafiltration membrane by phase-inversion method for high temperature condensed water treatment. The obtained high molecular weight co-polymers with fluorene group with good solubility and good thermal stability, can be easily cast into flexible, white and non-transparent flat films. The influence of molar ratio of BPA and BHPF on the properties of the prepared co-polymers and membranes was investigated in detail. SEM study of the morphology of the membranes indicated that the prepared membranes possessed homogeneous pores on the top surface and were sponge-like or finger-like in cross-section. Pure water flux of the membranes increased from 71.87 L·m⁻²·h⁻¹ to 247.65 L·m⁻²·h⁻¹, while the retention of BSA decreased slightly, and the water contact angle decreased from 82.1° to 55.6° with the PVP concentration from 0 wt% to 10 wt%. With increasing concentration of PVP, the mechanical properties of membranes decreased, while the thermal stability increased. The permeate flux measurement showed that the PAESK membrane had the potential for high temperature condensed water treatment.
- Poly(aryl ether sulfone ketone),
- Fluorene group,
- Thermal stability,
- Ultrafiltration membrane
1. [1]
  Zhao, S. S.; Wang, P.; Wang, C.; Sun, X.; Zhang, L. H. Thermostable PPESK/TiO₂ nanocomposite ultrafiltration membrane for high temperature condensed water treatment. Desalination 2012, 299, 35−43 doi: 10.1016/j.desal.2012.05.013
2. [2]
  Leng, S. Purifying techniques of condensed water. Ind. Water Treat. 2010, 30, 64−67
3. [3]
  Caissie, D. The thermal regime of rivers: a review. Freshw. Biol. 2006, 51, 1389−1406 doi: 10.1111/fwb.2006.51.issue-8
4. [4]
  Verones, F.; Hanafish, M. M.; Pfister, S.; Huijbregts, M. A. J.; Pelletier G. J.; Koehler, A. Characterization factors for thermal pollution in freshwater aquatic environments. Environ. Sci. Technol. 2010, 44, 9364−9369 doi: 10.1021/es102260c
5. [5]
  Arieli, R. N.; Labin, A. A.; Abramovich, S.; Herut, B. The effect of thermal pollution on benthic foraminiferal assemblages in the mediterranean shoreface adjacent to Hadera power plant (Israel). Mar. Pollut. Bull. 2011, 62, 1002−1012 doi: 10.1016/j.marpolbul.2011.02.036
6. [6]
  Zhai, J. W.; Luo, M.; Wang, D.; Wu, Z. Z.; Wu, D. W. Application of high-temperature tolerance membrane in condensation water deep purification and treatment. Chem. Ind. Eng. Prog. 2009, 28, 69−71
7. [7]
  Yeon, K. H.; Song, J. H.; Moon, S. H. A study on stack configuration of continuous electrodeionization for removal of heavy metal ions from the primary coolant of nuclear power plant. Water Res. 2004, 38, 1911−1921 doi: 10.1016/j.watres.2004.01.003
8. [8]
  Lim, T. T.; Huang, X. F. Evaluation of hydrophobicity/ oleophilicity of kapok and its performance in oily water filtration: Comparison of raw and solvent-treated fivers. Ind. Crops Prod. 2007, 26, 125−134 doi: 10.1016/j.indcrop.2007.02.007
9. [9]
  Strathmann, H. Synthetic membranes and their preparation. Noyes Publications, New Jersey, 1990
10. [10]
  Coutinho, C. M.; Chiu, M. C.; Basso, R. C.; Ribeiro, A. P. B.; Goncalves, L. A. G.; Viotto, L.A. State of art of the application of membrane technology to vegetable oils: A review. Food Res. Int. 2009, 42, 536−550 doi: 10.1016/j.foodres.2009.02.010
11. [11]
  Yang, D. L.; Jin, Z.; Zhang, S. H.; Jian, X. G. Preparation and characterazition of poly(phthalazinone ether sulfone ketone) hollow fiber ultrafiltration membrane with high-molecular weight cut-off. J. Membr. Sci. 2007, 306, 253−260 doi: 10.1016/j.memsci.2007.08.044
12. [12]
  Yun, Y. B.; Tian, Y. H.; Shi, G. L.; Li, J. D.; Chen, C. X. Preparation, morphologies and properties for flat sheet PPESK ultrafiltration membranes. J. Membr. Sci. 2006, 270, 146−153 doi: 10.1016/j.memsci.2005.06.050
13. [13]
  Jian, X. G.; Yan, C.; Zhang, H. M.; Zhang, S. H.; Liu, C.; Zhao, P. Syethesis and characterization of quaternized poly(phthalazinone ether sulfone ketone) for anion exchange membrane. Chin. Chem. Lett. 2007, 18, 1269−1272 doi: 10.1016/j.cclet.2007.08.022
14. [14]
  Sun, W. N.; Chen, C. X.; Li, J. D.; Lin, Y. Z. Ultrafiltration membrane formation of PES-C, PES and PPESK polymers with different solvents. Chinese J. Polym. Sci. 2009, 27, 165−172 doi: 10.1142/S0256767909003790
15. [15]
  Zhu, L. P.; Xu, Y. Y.; Wei, X. Z.; Zhu, B. K. Hydrophilic modification of poly(phthalazine ether sulfone ketone) ultrafiltration membranes by the surface immobilization of poly(ethylene glycol) acrylates. Desalination 2009, 242, 96−109 doi: 10.1016/j.desal.2008.03.034
16. [16]
  Shimura, T.; Miyatake, K.; Watanabe, M. Poly(arylene ether) ionomers containing sulfofluorenyl groups: Effect of electron-withdrawing groups on the properties. Eur. Polym. J. 2008, 44, 4054−4062 doi: 10.1016/j.eurpolymj.2008.09.017
17. [17]
  Harrison, W. L.; Wang, F.; Mecham, J. B.; Bhanu, V. A.; Hill, M.; Kim, Y. S.; McGrath, J. E. Influence of the bisphenol structure on the direct synthesis of sulfonated poly(arylene ether) copolymers. I. J. Polym. Sci., Part A: Polym. Chem. 2003, 41, 2264−2276
18. [18]
  Zhu, L. P.; Du, C. H.; Xu, L.; Feng, Y. X.; Zhu, B. K.; Xu, Y. Y. Amphiphilic PPESK-g-PEG graft copolymers for hydrophilic modification of PPESK microporous membranes. Eur. Polym. J. 2007, 43, 1383−1393 doi: 10.1016/j.eurpolymj.2007.01.037
19. [19]
  Palaniappan, S. Benzoyl peroxide as a novel oxidizing agent in polyaniline dispersion: Synthesis and characterization of a pure polyaniline−poly(vinyl pyrrolidone) composite. J. Appl. Polym. Sci. 2008, 108, 825−832 doi: 10.1002/(ISSN)1097-4628
20. [20]
  Chakrabarty, B.; Ghoshal, A. K.; Purkait, A. K. Preparation, Characterization and performance studies of polysulfone membranes using PVP as an additive. J. Membr. Sci. 2008, 315, 36−47 doi: 10.1016/j.memsci.2008.02.027
21. [21]
  Han, M. J.; Nam, S. T. Thermodynamic and rheological variation in polysulfone solution by PVP and its effect in the preparation of phase inversion membrane. J. Membr. Sci. 2002, 202, 55−61 doi: 10.1016/S0376-7388(01)00718-9
22. [22]
  Smolders, C. A.; Reuvers, A. J.; Boom, R. M.; Wienk, I. M. Microstructures in phase inversion membranes. Part 1. Formation of macrovoids. J. Membr. Sci. 1992, 73, 259−275 doi: 10.1016/0376-7388(92)80134-6
23. [23]
  Liu, H. Y.; Zhang, G. Q.; Zhao, C. Q.; Liu, J. D.; Yang, F. L. Hydraulic power and electric field combined antifouling effect of a novel conductive poly(aminoanthraquinone)/reduced grapheme oxide nanohybrid blended PVDF ultrafiltration membrane. J. Mater. Chem. A 2015, 3, 20277−20287 doi: 10.1039/C5TA05306D
1. [1]
  Guizhi Zhu , Junrui Tan , Longfei Tan , Qiong Wu , Xiangling Ren , Changhui Fu , Zhihui Chen , Xianwei Meng . Growth of CeCo-MOF in dendritic mesoporous organosilica as highly efficient antioxidant for enhanced thermal stability of silicone rubber. Chinese Chemical Letters, 2025, 36(1): 109669-. doi: 10.1016/j.cclet.2024.109669
2. [2]
  Shi Li , Wenshuai Zhao , Yong Qi , Wenbin Niu , Wei Ma , Bingtao Tang , Shufen Zhang . Hydrogen bonding induced ultra-highly thermal stability of azo dyes for color films. Chinese Chemical Letters, 2025, 36(9): 110653-. doi: 10.1016/j.cclet.2024.110653
3. [3]
  Shunshun Jiang , Ji Zhang , Jing Wang , Shan-Tao Zhang . Excellent energy storage properties in non-stoichiometric Bi_0.5Na_0.5TiO₃-based relaxor ferroelectric ceramics. Chinese Chemical Letters, 2024, 35(7): 108955-. doi: 10.1016/j.cclet.2023.108955
4. [4]
  Bo Yang , Pu-An Lin , Tingwei Zhou , Xiaojia Zheng , Bing Cai , Wen-Hua Zhang . Facile surface regulation for highly efficient and thermally stable perovskite solar cells via chlormequat chloride. Chinese Chemical Letters, 2024, 35(10): 109425-. doi: 10.1016/j.cclet.2023.109425
5. [5]
  Zhilei Zhang , Yanan Sun , Xiaosong Shi , Xiaozhe Yin , Dawei Liu , Erjing Wang , Jie Liu , Yuanyuan Hu , Lang Jiang . Molecular tailoring towards two-dimensional organic crystals at the thickness limit. Chinese Chemical Letters, 2025, 36(9): 110786-. doi: 10.1016/j.cclet.2024.110786
6. [6]
  Qi Li , Minqiao Liang , Huifen Zhuang , Zhengyang Chen , Yuxiang Jiang , Xiaofei Chen , Yifa Chen , Ya-Qian Lan . Underscoring the polyimide-linkage in covalent organic frameworks and related applications. Chinese Chemical Letters, 2026, 37(2): 111593-. doi: 10.1016/j.cclet.2025.111593
7. [7]
  Yuchen Zhou , Huanmin Liu , Hongxing Li , Xinyu Song , Yonghua Tang , Peng Zhou . Designing thermodynamically stable noble metal single-atom photocatalysts for highly efficient non-oxidative conversion of ethanol into high-purity hydrogen and value-added acetaldehyde. Acta Physico-Chimica Sinica, 2025, 41(6): 100067-0. doi: 10.1016/j.actphy.2025.100067
8. [8]
  Xiqing Liang , Tian Zhao , Jiawei Li , Haohui Tan , Hai Chen , Liyan Zeng . Pentaerythritol’s Journey of Making Friends. University Chemistry, 2025, 40(10): 175-185. doi: 10.12461/PKU.DXHX202412009
9. [9]
  Ningning Gao , Yue Zhang , Zhenhao Yang , Lijing Xu , Kongyin Zhao , Qingping Xin , Junkui Gao , Junjun Shi , Jin Zhong , Huiguo Wang . Ba²⁺/Ca²⁺ co-crosslinked alginate hydrogel filtration membrane with high strength, high flux and stability for dye/salt separation. Chinese Chemical Letters, 2024, 35(5): 108820-. doi: 10.1016/j.cclet.2023.108820
10. [10]
  Yujin Li , Paramaguru Ganesan , Abd Rashid bin Mohd Yusoff , Simonetta Orlandi , Peng Gao . Fluorene chemistry as a design platform for polymeric HTLs: Substituent control and core linkages in perovskite photovoltaics. Chinese Journal of Structural Chemistry, 2026, 45(3): 100828-100828. doi: 10.1016/j.cjsc.2025.100828
11. [11]
  Mei Peng , Wei-Min He . Photochemical synthesis and group transfer reactions of azoxy compounds. Chinese Chemical Letters, 2024, 35(8): 109899-. doi: 10.1016/j.cclet.2024.109899
12. [12]
  Huiping Shi , Shaojun Peng , Minghui Yang , Yuanyu Huang . Engineering circular RNA with Tetrahymena group Ⅰ intron ribozyme. Chinese Chemical Letters, 2025, 36(9): 111160-. doi: 10.1016/j.cclet.2025.111160
13. [13]
  Juan Guo , Mingyuan Fang , Qingsong Liu , Xiao Ren , Yongqiang Qiao , Mingju Chao , Erjun Liang , Qilong Gao . Zero thermal expansion in Cs₂W₃O₁₀. Chinese Chemical Letters, 2024, 35(7): 108957-. doi: 10.1016/j.cclet.2023.108957
14. [14]
  Mengfan Zhang , Lingyan Liu , Peng Wei , Wei Feng , Tao Yi . A proximity tagging strategy utilizing an activated aldehyde group as the active site. Chinese Chemical Letters, 2025, 36(4): 110127-. doi: 10.1016/j.cclet.2024.110127
15. [15]
  Zihe SONG , Jinjin ZHAO , Ning REN , Jianjun ZHANG . Crystal structure, thermal analysis, and luminescence properties of six heterocyclic lanthanide complexes. Chinese Journal of Inorganic Chemistry, 2026, 42(1): 181-192. doi: 10.11862/CJIC.20250126
16. [16]
  Jianwen Zhao , Shuai Wang , Shanshan Zhao , Liwei Chen , Fangang Meng , Xuelin Tian . A non-fluorinated liquid-like membrane with excellent anti-scaling performance for membrane distillation. Chinese Chemical Letters, 2025, 36(1): 109883-. doi: 10.1016/j.cclet.2024.109883
17. [17]
  Man Xu , Qianyi Li , Jingyao Ma , Hao Li , Yunfei Zhu , Fan Yu , Kuande Wang , Tao Zhou , Quanyou Feng , Linghai Xie , Jinyi Lin . Wide bandgap steric carbazole-fluorene-nanogrid polymers via metal-free CN polymerization for deep-blue polymer light-emitting diodes. Chinese Chemical Letters, 2026, 37(1): 111551-. doi: 10.1016/j.cclet.2025.111551
18. [18]
  Gaofeng WANG , Shuwen SUN , Lixin Meng , Dequn PENG . Syntheses and fluorescent sensing properties of two coordination polymers based on 9, 9′-dihexyl-2, 7-di(pyridin-4-yl)fluorene. Chinese Journal of Inorganic Chemistry, 2026, 42(2): 331-339. doi: 10.11862/CJIC.20250260
19. [19]
  Yixin Zhang , Ting Wang , Jixiang Zhang , Pengyu Lu , Neng Shi , Liqiang Zhang , Weiran Zhu , Nongyue He . Formation mechanism for stable system of nanoparticle/protein corona and phospholipid membrane. Chinese Chemical Letters, 2024, 35(4): 108619-. doi: 10.1016/j.cclet.2023.108619
20. [20]
  Zixuan Chen , Yafeng Wu , Zhaoyan Tian , Zhaohan Wang , Weiwei Liu , Songqin Liu . A reproducible hybrid membrane for in situ analysis of cell secretions with a wide size range. Chinese Chemical Letters, 2025, 36(12): 110917-. doi: 10.1016/j.cclet.2025.110917

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(1845)
HTML views(39)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142