Synergistic Effects of the ZnCl2-SiCl4 Modified TiCl4/MgCl2/THF Catalytic System on Ethylene/1-Hexene and Ethylene/1-Octene Copolymerizations

Citation: Wanna Phiwkliang, Bunjerd Jongsomjit, Piyasan Praserthdam. Synergistic Effects of the ZnCl2-SiCl4 Modified TiCl4/MgCl2/THF Catalytic System on Ethylene/1-Hexene and Ethylene/1-Octene Copolymerizations[J]. Chinese Journal of Polymer Science, 2014, 32(1): 84-91. doi: 10.1007/s10118-014-1380-6 shu

Synergistic Effects of the ZnCl2-SiCl4 Modified TiCl4/MgCl2/THF Catalytic System on Ethylene/1-Hexene and Ethylene/1-Octene Copolymerizations

1.
Center of Excellence on Catalysis and Catalytic Reaction Engineering, Department of Chemical Engineering, Faculty of Engineering, Chulalongkorn University, Bangkok 10330, Thailand
基金项目:
This work was financially supported by the Dusadeepipat scholarship at Graduate school of Chulalongkorn University, the Thailand Research Fund (TRF), the Higher Education Promotion and National Research University Development (AM1088A), and the office of the Higher Education Commission (CHE).

摘要: The copolymerizations of ethylene with 1-hexene or 1-octene by using TiCl4/MgCl2/THF catalysts modified with different metal halide additives (ZnCl2, SiCl4, and the combined ZnCl2-SiCl4) were investigated based on catalytic activity and copolymer properties. It was found that the catalyst modified with mixed ZnCl2-SiCl4 revealed the highest activities for both ethylene/1-hexene and ethylene/1-octene copolymerization. The increase in activities was due to the formation of acidic sites by modifying the catalysts with Lewis acids. Based on the FTIR measurements, the characteristic C―O―C peaks of the catalysts modified with metal halide additives were slightly shifted to lower wavenumber when compared to the unmodified catalyst. This showed that the modified catalysts could generate more acid sites in the TiCl4/MgCl2/THF catalytic system leading to an increase in activities as well as comonomer insertion (as proven by 13C-NMR). However, Lewis acid-modifications did not affect the microstructure of the copolymers obtained. By comparison on the properties of copolymers prepared with the unmodified catalyst, it was found that polymers with ZnCl2 and/or SiCl4 modification exhibited a slight decrease in melting temperature, crystallinity and density. It is suggested that these results were obtained based on the different amount of a-olefins insertion, regardless of the types of Lewis acids and comonomer.

关键词:

Ziegler-Natta catalyst
/ Lewis acid
/ Copolymerization of ethylene with -olefin
/ SiCl4
/ ZnCl2

English

Synergistic Effects of the ZnCl2-SiCl4 Modified TiCl4/MgCl2/THF Catalytic System on Ethylene/1-Hexene and Ethylene/1-Octene Copolymerizations

1.
Center of Excellence on Catalysis and Catalytic Reaction Engineering, Department of Chemical Engineering, Faculty of Engineering, Chulalongkorn University, Bangkok 10330, Thailand
Received Date: 04 March 2013
Revised Date: 06 May 2013
Available Online: 05 January 2014
Fund Project:
This work was financially supported by the Dusadeepipat scholarship at Graduate school of Chulalongkorn University, the Thailand Research Fund (TRF), the Higher Education Promotion and National Research University Development (AM1088A), and the office of the Higher Education Commission (CHE).

Abstract: The copolymerizations of ethylene with 1-hexene or 1-octene by using TiCl4/MgCl2/THF catalysts modified with different metal halide additives (ZnCl2, SiCl4, and the combined ZnCl2-SiCl4) were investigated based on catalytic activity and copolymer properties. It was found that the catalyst modified with mixed ZnCl2-SiCl4 revealed the highest activities for both ethylene/1-hexene and ethylene/1-octene copolymerization. The increase in activities was due to the formation of acidic sites by modifying the catalysts with Lewis acids. Based on the FTIR measurements, the characteristic C―O―C peaks of the catalysts modified with metal halide additives were slightly shifted to lower wavenumber when compared to the unmodified catalyst. This showed that the modified catalysts could generate more acid sites in the TiCl4/MgCl2/THF catalytic system leading to an increase in activities as well as comonomer insertion (as proven by 13C-NMR). However, Lewis acid-modifications did not affect the microstructure of the copolymers obtained. By comparison on the properties of copolymers prepared with the unmodified catalyst, it was found that polymers with ZnCl2 and/or SiCl4 modification exhibited a slight decrease in melting temperature, crystallinity and density. It is suggested that these results were obtained based on the different amount of a-olefins insertion, regardless of the types of Lewis acids and comonomer.

Key words:

Ziegler-Natta catalyst
/ Lewis acid
/ Copolymerization of ethylene with -olefin
/ SiCl4
/ ZnCl2

1. [1]
  [1] Quijada, R., Dupunt, J., Lacerda Miranda, M. S., Scipioni, R. B., Galland, G. B., Macromol. Chem. Phys., 1995, 196: 3991 [2] Kong, Y., Yi, J., Dou, X., Liu, W., Huang, Q., Gao, K., Yang, W., Polymer, 2010, 51: 3859 [3] Czaja, K., Bialek, M[J]., Polymer.2001, 42:2289- [4] Chen, Y. P., Fan, Z[J].Q., Eur. Polym. J.2006, 42:2441- [5] Xia, S., Fu, Z[J]., Huang, B., Xu, J., Fan, Z., J. Mol. Catal. A: Chem.2012, 355:161- [6] Meng, W., Li, H[J]., Li, J., Chen, B., J. Korean Chem. Soc.2011, 55:673- [7] Zifang, G., Wei, C., Junling, Z., Hongxu, Y., Chinese J. Polym. Sci., 2009, 17(3): 530 [8] Wannaborworn, M., Praserthdam, P., Jongsomjit, B., Molecules, 2011, 16: 373 [9] Chaichana, E., Khaubunsongserm, S[J]., Praserthdam, P., Jongsomjit, B., Express Polym. Lett.2010, 4:94- [10] Kalita, A., Boruah, M., Das, D., Dolui, S. K., J. Polym. Res., 2012, 19(9892): 1 [11] Jiamwijitkul, S., Jongsomjit, B., Praserthdam, P., Iran. Polym. J., 2007, 16: 549 [12] Kaivalchatchawal, P., Samingprai, S., Shiono, T., Praserthdam, P., Jongsomjit, B., Eur. Polym. J., 2012, 48: 1304 [13] R?nkk?, H. L., Knuuttila, H., Linnolahti, M., Haukka, M., Pakkanen, T. T., Denifl, P., Leinonen, T., Inorg. Chim. Acta., 2011, 371: 124 [14] Hakim, S., Nekoomanesh, M., Nieat, M. A., Iran. Polym. J., 2008, 17: 209 [15] Chang, H. S., Song, W. D., Chu, K. J., Ihm, S. K., Macromolecules, 1992, 25: 2086 [16] Garofi, T., Leinonen, T[J]., J. Mol. Catal.1996, 104:205- [17] Fregonese, D., Bresadola, S[J]., Mol. Catal. A: Chem.1999, 145:265- [18] Chen, Y. P., Fan, Z[J].Q., Liao, J. H., Liao, S. Q., J. Appl. Polym. Sci.2006, 102:1768- [19] Randall, J. C., J[J].Polym. Sci. 2: Polym. Phys.1973, 11:275- [20] Soga, K., Uozumi, T., Park, J. R., Macromol. Chem. Phys., 1990, 191: 2853 [21] Zhikang, X., Linxian, F., Shiling, Y., Chinese J. Polym. Sci., 1994, 12: 1993 [22] Carlini, C., DAlessio, A., Giaiacopi, S., Po, R., Pracella, M., Raspolli Galletti, A., Sbrana, G., Polymer, 2007, 48: 1185 [23] Chu., K. J., Chang, H. S., Ihm, S.K., Eur. Polym. J., 1994, 30: 1467 [24] Kim, J. H., Macromol[J].Rapid Commun.1995, 16:113- [25] Seenivasan, K., Sommazzi, A., Bonino, F,. Bordiga, S., Groppo, E., Chem. Eur. J., 2011, 17: 8648 [26] Wannaborworn, M., Jongsomjit, B., Iran. Polym. J., 2009, 18: 969 [27] Bialek, M., Czaja, K[J]., Polymer.2000, 41:7899- [28] Taniike, T., Nguyen, B. T., Takahashi, S., Vu, T. Q., Ikeya, M., Terano, M., Polym. Chem., 2011, 49: 4005 [29] Nejad, M. H., Ferrari, P[J]., Pennini, G., Cecchin, G., J. Appl. Polym. Sci.2008, 108:3388- [30] Czaja, K., Bialek, M[J]., Utrata, A., J. Polym. Sci. A Polym. Chem.2004, 42:2512-

扫一扫看文章

计量

PDF下载量: 0
文章访问数: 838
HTML全文浏览量: 32

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Synergistic Effects of the ZnCl2-SiCl4 Modified TiCl4/MgCl2/THF Catalytic System on Ethylene/1-Hexene and Ethylene/1-Octene Copolymerizations

English

Synergistic Effects of the ZnCl2-SiCl4 Modified TiCl4/MgCl2/THF Catalytic System on Ethylene/1-Hexene and Ethylene/1-Octene Copolymerizations

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

Synergistic Effects of the ZnCl2-SiCl4 Modified TiCl4/MgCl2/THF Catalytic System on Ethylene/1-Hexene and Ethylene/1-Octene Copolymerizations

English

Synergistic Effects of the ZnCl2-SiCl4 Modified TiCl4/MgCl2/THF Catalytic System on Ethylene/1-Hexene and Ethylene/1-Octene Copolymerizations

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南： 你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

文章相关

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs